I have a m170 that I'm finishing.I have had the motor rebuilt and cant get it running corect.
.It idles good but will only goes 20 miles a hour,it doesn't spit and sputter just doesn't go.
Put a vacume gauge on and I have a steady 15 lbs at idle but when I give it gas it drops to nothing then back to 15.any sugestions would be greatly appreciated.
G503.com Message Forums
Military Vehicles, WWII Jeeps and more!
motor issue
Moderator: Moderator
5 posts
• Page 1 of 1
motor issue
by mayor » Thu May 31, 2012 4:50 pm
Last edited by mayor on Thu May 31, 2012 5:25 pm, edited 2 times in total.
- mayor
- G-Civilian
- Posts: 1
- Joined: Thu May 31, 2012 1:43 pm
Re: motor issue
by artificer » Thu May 31, 2012 5:10 pm
You need to do a few things:
If it is idling well & you don't get to full RPM you need to check & adjust the throttle levers/cables so that when the accelerator is @ the flootr the throttle butterfly is all the way open [first of all] then let us know more after you have done this.
If it is idling well & you don't get to full RPM you need to check & adjust the throttle levers/cables so that when the accelerator is @ the flootr the throttle butterfly is all the way open [first of all] then let us know more after you have done this.
John GIBBINS [EX A.R.A., A.Res & RAAFSR]....ASE Master Truck & Auto Technician
-
artificer - - R.A.E.M.E -
- Posts: 7885
- Joined: Tue Jul 11, 2006 11:46 am
- Location: LAX....over the Pacific Friday/Saturday night.
Re: motor issue
by Ben Dover » Thu May 31, 2012 6:23 pm
There is a square block on the rod from the Accelerator Pedal to the Bellcrank that is mounted on the rear stud of the exhaust valve cover, loosen the adjusting nut on the front side of the block a ways while pushing the rod over the rocker cover until the throttle is wide open and turn the rear adjusting nut until the accelerator pedal will open th throttle all the way. (With the engine not running) :wink:
PROUD 2011 MVPA PIONEER AWARDEE-HONOR GRAD WHEELED VEHICLE MECHANIC SCHOOL 1960- US ARMY ORDNANCE SCHOOL(MACHINIST) APG 1962 - O-1 BIRD DOG CREWCHIEF - 68 NONSTOP BY THE BOOK ARMY TRUCK-JEEP YEARS LIFETIME AM LEGION DAV 40/8- MVPA 1064 -7 TURNKEY MV'S
- Ben Dover
- Gee Addict
- Posts: 22645
- Joined: Sun Mar 02, 2008 2:37 pm
- Location: Proving Ground
5 posts
• Page 1 of 1
Return to M38a1 Technical Knowledge Base
Who is online
Users browsing this forum: No registered users and 2 guests